Operation of lifting platform and operation knowledge of mobile lifting platform

Update:01 Nov 2019
Summary:

In order to ensure the safe use of the lifting platform […]

In order to ensure the safe use of the lifting platform, combined with the relevant regulations and rules, the safety operation regulations of the lifting platform are specially formulated.
1. The lifting platform must be equipped with professional operators who have received special training, passed the examination and have certificates
2. The operator of the lifting platform must start the lifting platform according to the maintenance regulations of the mechanical equipment and carry out various inspections and maintenance. Before work, check the working range of the lifting platform car and remove the obstacles that hinder the turning and walking of the lifting platform car
3. The support is an important preparation for the operation of the lifting platform, and the flat ground shall be selected. If the foundation is soft or uneven, the work can only be carried out after the sleeper is padded
4. Generally, the lifting platform should lift the lower arm first, then the middle arm, and finally the upper arm. During the slewing operation of the lifting platform, the slewing can only be carried out after the lower arm is raised to a certain height, and the slewing shall be slow. At the same time, pay attention to whether the distance between the arm and platform to each equipment meets the safety requirements.
5. The operators on the working platform shall wear safety belts. When working in the live area, the vehicle body shall be grounded according to the regulations. The lifting platform climbing operation shall be commanded by the person in charge of the work. The person in charge shall contact the lifting platform operator according to the signals specified in the standards. The signal must be clear and accurate
6. Before the operation of lifting platform, the person in charge of the work shall explain the technology and safety to the operator, including: work content and requirements; safety precautions and dangerous points; personnel division and responsibility scope. The person in charge of the work shall not only check the vehicle condition and operators, but also check whether the terrain environment, take-off and landing meet the requirements of safety technical measures or the work plan formulated in advance. If there is any discrepancy, corresponding measures shall be formulated before starting the work
7. If there is any conflict between this provision and the national or industrial regulations, the national or industrial regulations shall prevail
I. The use of the lifting platform must be operated by the personnel designated by the Department (for the record of the personnel security department) and strictly observe the work position; non designated personnel are not allowed to use it without permission
2. Before starting the lifting platform, first check whether the doors of each floor are closed, whether the emergency stop switch is reset, (the emergency stop switch is reset, turn clockwise) and check the side of the emergency stop switch, and then start the operation
III. It is forbidden to ride on the lifting platform. Huanan Junye | straight top elevator | scissor elevator | Junye lifting platform
IV. the lifting platform shall not be overloaded
V. when using the lifting platform to transport goods up and down, put the goods in the middle of the car as far as possible, so as to avoid the goods from being damaged due to inclination during operation, and do not start the platform when the goods are not stably stacked. Guangdong lifting platform
Vi. if the platform is found to be abnormal during use, the operator shall immediately stop the operation of the platform and report to the equipment department for maintenance; if the fault is not eliminated, it is forbidden to use the platform and hang a sign for warning. Elevator manufacturer
VII. After the lifting platform is used, the operator stops the platform at the bottom floor, closes the landing door, closes the key power switch, and closes the main power supply
Mobile lifting platform is an indispensable equipment in high-rise buildings. It also brings us many conveniences in ordinary days. The following are the strictly prohibited items for operating lifting platform:
1. It is forbidden to smoke and make fire at the lifting goods elevator site with dangerous and inflammable goods by using the mobile lifting platform
2. It is forbidden for any person to operate, stand and walk under the lifting frame, basket, well head of lifting frame and lifting objects by using the mobile lifting platform
3. It is forbidden to play, shout and throw all objects from high place at the operation site of the elevator
4. It is forbidden to use the mobile lifting platform to carry out the dangerous work of lifting goods elevator in the high-voltage power risk area
5. It is forbidden to work up and down in the same part without safety measures
6. It is forbidden to work at heights without railings or other safety measures and walk on one-way walls by using mobile lifting platform
7. It is forbidden to use the mobile lifting platform to work on the construction site without wearing slippers, safety helmet, work permit and children.

https://www.heirrmu.com/